Product ID:MIL-C-10578 D TYPE II
MSDS Date:01/01/1987
FSC:6850
NIIN:00-174-9672
MSDS Number: BYDCS

MINNESOTA MINING AND MFG CO IDENTIFICATION AND CONVERTOR

3M CTR
SAINT PAUL, MN 55144-1000
US

Emergency Phone: NONE

Info Phone: 612-737-4380

Cage: 76381

MINNESOTA MINING AND MFG CO, DBA 3M

SAINT PAUL, MN 55144-1000 US

Telephone: 866-556 5712 / 612-733-1110

Cage: 76381

PHOSPHORIC ACID (SARA 313) (CERCLA); 85%

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 14%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3/3 STEL; 9495

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYLENE GLYCOL MONOBUTYL ETHER/2-BUTOXYETHANOL

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 25%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9495

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- CORROSIVE. EYE OR SKIN CONTACT MAY CAUSE
CHEMICAL BURNS. MAY CAUSE PERMANENT EYE DAMAGE. INHALING
MIST/VAPORS MAY CAUSE SEVERE RESPIRATORY IRR ITATION & BURNS.
INGESTION MAY CAUSE TISSUE DAMAGE & BURNS TO MOUTH, THROAT &
DIGESTIVE TRACT. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, BURNS, DIFFICULTY IN
BREATHING, PAIN, NAUSEA, VOMITING, COUGHING
Medical Cond Aggravated by Exposure:SKIN IRRITATION MAY BE AGGRAVATED
IN PERSONS WITH EXISTING SKIN LESIONS. MISTS MAY AGGRAVATE ACUTE OR
CHRONIC ASTHMA OR OTHER RESPIRATORY DISEASES.

First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYE/SKIN:IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. HOLD EYELIDS OPEN.
INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED. ORAL:DO
NOT INDUCE VOMI TING. RINSE MOUTH AT ONCE. THEN DRINK LARGE AMOUNT
OF WATER/MILK, FOLLOWED BY MILK OF MAGNESIA (20 ML). IF VOMITING
OCCURS, DRINK FLUID REPEATEDLY. TAKE FLUID SUCH AS MILK/BEATEN EGGS
EVERY 2 HOURS.

Flash Point:NONE

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. DIKE SPILL WITH
SAND OR CLAY TO KEEP IT OUT OF SEWER SYSTEM. NEUTRALIZE WITH SODA
ASH. REQUIRES GOOD VENTILATION AS CO2 IS PRODUCED. PLACE
NEUTRALIZED SPILL IN DOT APPROVED CONTAINER/FLUSH TO SEWER WITH
WATER IFPERMITTED.
Neutralizing Agent:SODA ASH, LIME

Handling and Storage Precautions:STORE IN CLOSED CONTAINERS AWAY FROM
INCOMPATIBLE MATERIALS.
Other Precautions:WARNING! CORROSIVE. KEEP OUT OF REACH OF CHILDREN. DO
NOT GET IN EYES, ON SKIN OR ON CLOTHING. AVOID BREATHING MISTS OR
VAPORS. WASH THOROUGHLY AFTER HANDLING. DO NOT INGEST.

Respiratory Protection:USE A NIOSH-APPROVED RESPIRATOR FOR ACID MISTS
WHEN HANDLING SPILLS, LEAKS OR WHEN AIRBORNE CONCENTRATIONS EXCEED
EXPOSURE LIMITS.
Ventilation:PROVIDE SUFFICIENT GENERAL OR LOCAL EXHAUST VENTILATION TO
CONTROL INHALATION EXPOSURES BELOW OSHA'S PEL.
Protective Gloves:NEOPRENE OR RUBBER
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:EYE WASH STATION & EMERGENCY SHOWER SHOULD
BE IN CLOSE PROXIMITY. USE OF RUBBERIZED COVERALLS & RUBBER SHOES
SUGGESTED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
TABLE 1 OF MIL-C-10578D, AMENDMENT 2, 28 AUGUST 1987 GIVES THE MINIMUM
AMOUT OF PHOSPHORIC ACID CONTENT FOR TYPE II, GMS/100 ML AS 20-25.

HCC:C1

Hazardous Decomposition Products:TOXIC FUMES OF PHOSPHORUS OXIDES MAY
BE FORMED.

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
NEUTRALIZED SOLUTION MAY BE FLUSHED TO SEWER IF ALLOWED. RINSE DRUM
THOROUGHLY. RECYCLE DRUM OR DISCARD.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.